transwest RV repair center Oasis Network Fontana        Ford RV Repair        Cummins Motorhome engine repair        Detroit Diesel Engine repair        CAT engine repair Fontana      Freightliner Custom Chassis Motorhome Service      winnebago

TransWest RV Center is your best choice for RV & Motorhome Repair in Fontana California.


10150 Cherry Avenue Fontana CA 92335
Call for Service (909) 770-5620

FREIGHTLINER CUSTOM CHASSIS FACTORY MAINTENANCE SCHEDULE


 

6,000 Mile or 6 Month Initial Maintenance

Inspect

  • Engine Drive Belt

  • Charge Air Cooler (CAC), cleaning if needed

  • Transmission Hose Routing for Chaffing and Leaks

  • V-Ride Rear Suspension Inspection

  • Wheel End Inspection

  • Brake System Valves Inspecting

  • Air Dryer and Air Lines for Proper Routing, Chaffing, and Leaks

  • Bendix Hydro-Max Brake System Inspection (Front-Engine Only)

  • Brake Inspecting (Air Brakes)

  • Versajust Slack Adjuster Inspection

  • Fuel Tank Mounts and Fuel Line

  • Exhaust System Inspecting

  • Air Conditioner Component Inspection

Lubricate

  • Throttle Pedal Pivot Pin Lubricating

  • ZF IFS Lubrication

  • Knuckle Pin Lubricating

  • Tie-Rod End Lubricating and Inspecting

  • Driveline Inspection and Lubrication

  • Camshaft Bracket Bushing Lubricating

  • Slack Adjuster Lubriation

  • Foot Brake Valve Actuator Lubrication

  • Brake Caliper Slide Pin Lubrication, Bosch Brakes (Front-Engine Diesel Chassis)

  • Versajust Slack Adjuster Lubrication

  • Drag Link Lubrication

  • Steering Driveline Lubrication

  • Steering Gear Lubrication

Change

  • Engine Oil and Filter

  • Mechanical Fan Drive Gearbox Oil change

  • Transmission Fluid and Filter (if required by All)

  • Oil-Filled Hubs Oil Changing (Front & Tag Axle)

  • Axle Lubricant Changing and Magnetic Plug

  • Cleaning (Detroit and Meritor Axles)

  • Drain Air Tank and Replace

  • Hydraulic Reservoir Filter Change

  • Fuel Filters

Check

  • Engine-Support Fasteners

  • Alternator, Battery, and Starter Connections

  • Radiator (radiator cap, coolant freeze points, SCA levels, hose routing for chaffing and leaks)

  • Suspension Fastener Torque Check

  • Suspension Height Control Valve Check

  • Suspension U-Bolt Torque Check

  • All Axle Alignment

  • Axle Seals for Leaks

  • Axle Breather

  • Wheel Nut Checking

  • Tire Pressure

  • Brake Lines Checking, Hydraulic Disc or Air Brakes

  • Brake Lining Wear Checking, Hydraulic Disc Brakes (Front-Engine Only)

  • Ground Cables Checking and Cleaning


 

15,000 Mile or 12 Month Initial Maintenance

Inspect

  • Engine Drive Belt

  • Air Cleaner Inspection

  • Charge Air Cooler (CAC), cleaning if needed

  • Air Compressor Inspection

  • Transmission Hose Routing for Chaffing and Leaks

  • V-Ride Rear Suspension Inspection

  • Wheel End Inspection

  • Brake System Valves Inspecting

  • Air Dryer and Air Lines for Proper Routing, Chaffing, and Leaks

  • Bendix Hydro-Max Brake System Inspection (Front-Engine Only)

  • Brake Inspecting (Air Brakes)

  • Versajust Slack Adjuster Inspection

  • Fuel Tank Mounts and Fuel Line

  • Exhaust System Inspecting

  • Air Conditioner Component Inspection

Lubricate

  • Mechanical Fan Drive Gearbox

  • Throttle Pedal Pivot Pin Lubricating

  • ZF IFS Lubrication

  • Knuckle Pin Lubricating

  • Tie-Rod End Lubricating and Inspecting

  • Driveline Inspection and Lubrication

  • Camshaft Bracket Bushing Lubricating

  • Slack Adjuster Lubriation

  • Foot Brake Valve Actuator Lubrication

  • Brake Caliper Slide Pin Lubrication, Bosch Brakes (Front-Engine Diesel Chassis)

  • Meritor Roller Pin Lubrication

  • Versajust Slack Adjuster Lubrication

  • Drag Link Lubrication

  • Steering Driveline Lubrication

  • Steering Gear Lubrication

Change

  • Engine Oil and Filter

  • Transmission Fluid and Filter (if required by All)

  • Oil-Filled Hubs Oil Changing (Front & Tag Axle)

  • Axle Lubricant Changing and Magnetic Plug Cleaning (Detroit and Meritor Axles)

  • Drain Air Tank and Replace

  • Hydraulic Reservoir Filter Change

  • Fuel Filters

  • Power Steering Fluid and Filter Change

Check

  • Engine-Support Fasteners

  • Alternator, Battery, and Starter Connections

  • Radiator (radiator cap, coolant freeze points, SCA levels, hose routing for chaffing and leaks)

  • Suspension Fastener Torque Check

  • Suspension Height Control Valve Check

  • Suspension U-Bolt Torque Check

  • Axle Seals for Leaks

  • Axle Breather

  • Tire Pressure

  • Brake Lines Checking, Hydraulic Disc or Air Brakes

  • Brake Lining Wear Checking, Hydraulic Disc Brakes (Front-Engine Only)

  • Ground Cables Checking and Cleaning


 

30,000 Mile or 24 Month Initial Maintenance

Inspect

  • Engine Drive Belt

  • Charge Air Cooler (CAC), cleaning if needed

  • Air Compressor Inspection

  • Transmission Hose Routing for Chaffing and Leaks

  • V-Ride Rear Suspension Inspection

  • Wheel End Inspection

  • Brake System Valves Inspecting

  • Air Dryer and Air Lines for Proper Routing, Chaffing, and Leaks

  • Bendix Hydro-Max Brake System Inspection (Front-Engine Only)

  • Brake Inspecting (Air Brakes)

  • Versajust Slack Adjuster Inspection

  • Fuel Tank Mounts and Fuel Line

  • Exhaust System Inspecting

  • Air Conditioner Component Inspection

Lubricate

  • Mechanical Fan Drive Gearbox Lubrication

  • Throttle Pedal Pivot Pin Lubricating

  • ZF IFS Lubrication

  • Knuckle Pin Lubricating

  • Tie-Rod End Lubricating and Inspecting

  • Driveline Inspection and Lubrication

  • Camshaft Bracket Bushing Lubricating

  • Slack Adjuster Lubriation

  • Foot Brake Valve Actuator Lubrication

  • Brake Caliper Slide Pin Lubrication, Bosch Brakes (Front-Engine Diesel Chassis)

  • Meritor Roller Pin Lubrication

  • Versajust Slack Adjuster Lubrication

  • Drag Link Lubrication

  • Steering Driveline Lubrication

  • Steering Gear Lubrication

Change

  • Engine Oil and Filter

  • Air Cleaner Replacement

  • Mechanical Fan Drive Gearbox Oil Change

  • Transmission Fluid and Filter (if required by All)

  • Oil-Filled Hubs Oil Changing (Front & Tag Axle)

  • Axle Lubricant Changing and Magnetic Plug Cleaning (Detroit and Meritor Axles)

  • Drain Air Tank and Replace

  • Hydraulic Reservoir Filter Change

  • Fuel Filters

  • Power Steering Fluid and Filter Change

Check

  • Engine-Support Fasteners

  • Alternator, Battery, and Starter Connections

  • Radiator (radiator cap, coolant freeze points, SCA levels, hose routing for chaffing and leaks)

  • Suspension Fastener Torque Check

  • Suspension Height Control Valve Check

  • Suspension U-Bolt Torque Check

  • Axle Seals for Leaks

  • Axle Breather

  • Tire Pressure

  • Wheel Nut Check

  • Brake Lines Checking, Hydraulic Disc or Air Brakes

  • Brake Lining Wear Checking, Hydraulic Disc Brakes (Front-Engine Only)

  • Ground Cables Checking and Cleaning


 

45,000 Mile or 48 Month Initial Maintenance

Inspect

  • Engine Drive Belt

  • Charge Air Cooler (CAC), cleaning if needed

  • Air Compressor Inspection

  • Transmission Hose Routing for Chaffing and Leaks

  • V-Ride Rear Suspension Inspection

  • Wheel End Inspection

  • Brake System Valves Inspecting

  • Air Dryer and Air Lines for Proper Routing, Chaffing, and Leaks

  • Bendix Hydro-Max Brake System Inspection (Front-Engine Only)

  • Brake Inspecting (Air Brakes)

  • Versajust Slack Adjuster Inspection

  • Fuel Tank Mounts and Fuel Line

  • Exhaust System Inspecting

  • Air Conditioner Component Inspection

Lubricate

  • Mechanical Fan Drive Gearbox Lubrication

  • Throttle Pedal Pivot Pin Lubricating

  • ZF IFS Lubrication

  • Knuckle Pin Lubricating

  • Tie-Rod End Lubricating and Inspecting

  • Driveline Inspection and Lubrication

  • Camshaft Bracket Bushing Lubricating

  • Slack Adjuster Lubriation

  • Foot Brake Valve Actuator Lubrication

  • Brake Caliper Slide Pin Lubrication, Bosch Brakes (Front-Engine Diesel Chassis)

  • Meritor Roller Pin Lubrication

  • Versajust Slack Adjuster Lubrication

  • Drag Link Lubrication

  • Steering Driveline Lubrication

  • Steering Gear Lubrication

Change

  • Engine Oil and Filter

  • Air Cleaner Replacement

  • Mechanical Fan Drive Gearbox Oil Change

  • Transmission Fluid and Filter (if required by All)

  • Oil-Filled Hubs Oil Changing (Front & Tag Axle)

  • Axle Lubricant Changing and Magnetic Plug Cleaning (Detroit and Meritor Axles)

  • Drain Air Tank and Replace

  • Hydraulic Reservoir Filter Change

  • Fuel Filters

  • Power Steering Fluid and Filter Change

Check

  • Engine-Support Fasteners

  • Alternator, Battery, and Starter Connections

  • Radiator (radiator cap, coolant freeze points, SCA levels, hose routing for chaffing and leaks)

  • Suspension Fastener Torque Check

  • Suspension Height Control Valve Check

  • Suspension U-Bolt Torque Check

  • Axle Seals for Leaks

  • Axle Breather

  • Tire Pressure

  • Wheel Nut Checking

  • Brake Lines Checking, Hydraulic Disc or Air Brakes

  • Brake Lining Wear Checking, Hydraulic Disc Brakes (Front-Engine Only)

  • Ground Cables Checking and Cleaning